Hi, i need some technical help
Early diagnostic with a v/a scanner showed:
-Evaporative Emission System Leak Detection Pump, circuit Range/Performance
-02 Sensor Bank1 Sensor1, Malfunction
-02 Sensor Reference Voltage Circuit Bank1 Sensor1, Open
-Bank1, Sensor1, Heater Circuit, Electrical Malfunction
-Intake Manifold Runner Control Bank1 Stuck Closed
-Bank1 Camshaft Position, Timing Over-Advanced or System Performance
-Camshaft Position Sensor B Circ, Bank1, Range/Performance
The valve cover gasket seem to have an issue oil was leaking
I changed:
-Valve cover gasket on both sides
-Purge valve solenoid
-Spark plugs / ngk ruthenium
-Bank1 camshaft position sensor (under fuel pressure sensor)
-EGR vacuum Solenoid Valve
The battery stayed connected for a 2 week duration while i changed the parts
I disconnected fuel line and taped both sides from day 1 while i kept opening
and closing driver door for 2 weeks with the battery on, i think that caused an issue..
After that i started the car /test drove 10mn, everything seemed a bit better , parked the car
for 10mn, the car had trouble starting and was dying after 30sec it drives only a few meters then dies off..
VCDS 2 weeks later :
9 Faults Found:
009220 - EVAP Leak Detection Pump Sense Circuit
P2404 - 006 - Implausible Signal - MIL ON
Freeze Frame:
Fault Status: 10100001
Fault Priority: 4
Fault Frequency: 17
Reset counter: 40
Mileage: 260374 km
Time Indication: 0
Date: 2005.10.08
Time: 10:26:32
Freeze Frame:
RPM: 1120 /min
Mass Air / Rev.: 103.6 mg/str
Temperature: 60.0°C
Idle
Voltage: 13.77 V
Speed: 34.0 km/h
000304 - Oxygen (Lambda) Sensor B1 S1
P0130 - 006 - Malfunction in Circuit - Intermittent
Freeze Frame:
Fault Status: 00100001
Fault Priority: 5
Fault Frequency: 52
Reset counter: 40
Mileage: 260381 km
Time Indication: 0
Date: 2005.10.09
Time: 13:58:17
Freeze Frame:
RPM: 864 /min
Mass Air / Rev.: 179.9 mg/str
Temperature: 27.0°C
Idle
Voltage: 13.67 V
Bin. Bits: 00000010
008771 - Oxygen (Lambda) Sensor B1 S1
P2243 - 006 - Reference Voltage Open Circuit - MIL ON
Freeze Frame:
Fault Status: 10100001
Fault Priority: 5
Fault Frequency: 94
Reset counter: 40
Mileage: 260381 km
Time Indication: 0
Date: 2005.10.09
Time: 13:58:24
Freeze Frame:
RPM: 864 /min
Mass Air / Rev.: 163.5 mg/str
Temperature: 28.5°C
Idle
Time: 51.2 s
Bin. Bits: 00000100
008198 - Intake Manifold Flap; Bank 1
P2006 - 006 - Stuck Closed - Intermittent
Freeze Frame:
Fault Status: 00100001
Fault Priority: 4
Fault Frequency: 40
Reset counter: 38
Mileage: 260524 km
Time Indication: 0
Date: 2005.10.14
Time: 10:56:08
Freeze Frame:
RPM: 1024 /min
Mass Air / Rev.: 169.0 mg/str
Temperature: 15.0°C
Idle
Voltage: 2.400 V
Speed: 0.0 km/h
008196 - Intake Manifold Flap; Bank 1
P2004 - 007 - Stuck Open - Intermittent
Freeze Frame:
Fault Status: 00100010
Fault Priority: 4
Fault Frequency: 3
Reset counter: 39
Mileage: 263110 km
Time Indication: 0
Date: 2006.02.11
Time: 02:04:18
Freeze Frame:
RPM: 1280 /min
Mass Air / Rev.: 272.5 mg/str
Temperature: 21.0°C
Idle
Voltage: 3.040 V
Speed: 0.0 km/h
004176 - Bank1; Exhaust Cam Adjustment Valve 1 (N318)
P1050 - 009 - Open Circuit - Intermittent
Freeze Frame:
Fault Status: 00000100
Fault Priority: 4
Fault Frequency: 6
Reset counter: 39
Mileage: 263126 km
Time Indication: 0
Freeze Frame:
RPM: 0 /min
Mass Air / Rev.: 0.0 mg/str
Temperature: 7.5°C
Engine Off
Load: 0.0 %
Speed: 0.0 km/h
004180 - Bank2; Exhaust Cam Adjustment Valve 2 (N319)
P1054 - 009 - Open Circuit - Intermittent
Freeze Frame:
Fault Status: 00000100
Fault Priority: 4
Fault Frequency: 5
Reset counter: 39
Mileage: 263126 km
Time Indication: 0
Freeze Frame:
RPM: 0 /min
Mass Air / Rev.: 0.0 mg/str
Temperature: 7.5°C
Engine Off
Load: 0.0 %
Speed: 0.0 km/h
005416 - C
N205)
P1528 - 009 - Open Circuit - Intermittent
Freeze Frame:
Fault Status: 00000100
Fault Priority: 4
Fault Frequency: 4
Reset counter: 39
Mileage: 263126 km
Time Indication: 0
Freeze Frame:
RPM: 0 /min
Mass Air / Rev.: 0.0 mg/str
Temperature: 7.5°C
Engine Off
Load: 0.0 %
Speed: 0.0 km/h
000139 - Low Pressure Fuel System
P008B - 006 - Pressure too High - MIL ON
Freeze Frame:
Fault Status: 10100001
Fault Priority: 5
Fault Frequency: 5
Reset counter: 40
Mileage: 263126 km
Time Indication: 0
Date: 2006.03.01
Time: 06:55:43
Freeze Frame:
RPM: 672 /min
Mass Air / Rev.: 119.9 mg/str
Temperature: 90.0°C
Idle
Pressure: 11.9 bar
Speed: 0.0 km/h
Readiness: 0000 0100
-------------------------------------------------------------------------------
I Also have 5 codes from Battery Regulator / Quiescent Current Stage 1 to 5
What i am thinking about replacing ?
-Oxygen sensor
-Evap Leak Detection Pump
-Intake manifold runner control actuator
-2 VVT Solenoid ( bank1/bank2 )
-Intake Manifold Position Sensor
-Battery voltage regulator
-Vacuum Hose
-Fuel pressure senor
Any Advice would be helpful
Thanks
Reply With Quote
Bookmarks