PDA

View Full Version : s5 blues



RobinG
01-13-2019, 04:49 PM
I recently bought this 2011 S5 (75K mi) largely because the v8 sounds glorious. But it's an expensive mistress.

Lean misfire CEL to get it inspected ended up being $4000 and a month in the shop for:
- 2 hi-pressure fuel pumps
- intake carbon clean
- a couple injectors

Had it home for a month then the whole left headlight assembly went dark. I connected the left assembly to the right side connector and the assembly lit. The previous owner suffered an accident that cracked the lens on the left side that let moisture in, so I picked up a headlight assembly while troubleshooting. I compared the voltages on the headlight connectors and didn't get the same results on the left side.

The vagcom (below) lead me to think it was the J519 convenience module, since there were no obvious fuses blown. I replaced the module with the exact same ebay item, installed it, recoded it and got the same results, and my MMI display went dark. While under the dash everything looked stock, so I put the original module back in.

Since I don't have a schematic I really don't know where to look, so I'm guessing it's back to the stealership...

I also have a oil low light that won't go out even after I put the 1.5 quarts in. The hood latch appears to be working right and I tried to both short the connector and leave it open to bypass the micro switch and there was no effect.

On the last vagcom scan I noticed I have a flaky knock sensor 4 which I haven't been able to find any direction on where it's located.

Also noticed some very dark (looks like oil, tastes like antifreeze) antifreeze drips that are coming out on the left side where the lower control arm joins the body.

Any pointers would be appreciated:
======================
01-Engine -- Status: Malfunction 0010
03-ABS Brakes -- Status: OK 0000
04-Steering Angle -- Status: OK 0000
05-Acc/Start Auth. -- Status: OK 0000
06-Seat Mem. Pass -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: Malfunction 0010
10-Park/Steer Assist -- Status: OK 0000
15-Airbags -- Status: OK 0000
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
22-AWD -- Status: OK 0000
36-Seat Mem. Drvr -- Status: OK 0000
3C-Lane Change -- Status: OK 0000
42-Door Elect, Driver -- Status: OK 0000
46-Central Conv. -- Status: OK 0000
47-Sound System -- Status: OK 0000
52-Door Elect, Pass. -- Status: OK 0000
53-Parking Brake -- Status: OK 0000
55-Headlight Range -- Status: OK 0000
56-Radio -- Status: OK 0000
5F-Information Electr. -- Status: Malfunction 0010
6C-Back-up Cam. -- Status: OK 0000

-------------------------------------------------------------------------------
Address 01: Engine (J623-CAUB) Labels:. 079-907-560-CAU.clb
Part No SW: 8T0 907 560 AE HW: 8T0 907 560
Component: 4.2l V8/4V H17 0002
Revision: 76H17---
Coding: 01140009180F0120
Shop #: WSC 48635 000 1048576
VCID: 7DFA4075E4869CA2B0-8028

1 Fault Found:
004907 - Knock Sensor 4 (G199)
P132B - 008 - Electrical Malfunction in Circuit - Intermittent
Freeze Frame:
Fault Status: 00101000
Fault Priority: 2
Fault Frequency: 1
Reset counter: 255
Mileage: 124787 km
Time Indication: 0
Date: 2019.01.07
Time: 19:15:16

Freeze Frame:
RPM: 1874 /min
Load: 28.2 %
Speed: 15.0 km/h
Temperature: 85.0C
Temperature: 39.0C
Absolute Pres.: 980.0 mbar
Voltage: 13.081 V

Readiness: 0000 0000

-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519) Labels:. 8K0-907-063.clb
Part No SW: 8K0 907 063 P HW: 8K0 907 063 P
Component: BCM1 1.0 H29 0392
Revision: 10029001 Serial number: 00000000718835
Coding: 26001091063CAF212600080300003D3D0F9C93C80201016100 0000
Shop #: WSC 06325 000 00000
VCID: 3C7C8D71BF1C55AAC7-8068

Subsystem 1 - Part No SW: 8T1 955 119 D HW: 8J1 955 119 Labels: 1KX-955-119.CLB
Component: WWS 060710 H14 0070
Serial number: SWF10070065009
Coding: 00FD11

Subsystem 2 - Part No SW: 8K0 955 559 HW: 8K0 955 559 Labels: 8K0-955-559.CLB
Component: RLS H04 0003
Serial number: 10971895
Coding: 02532C

Subsystem 3 - Part No SW: 8K0 941 531 AN HW: 8K0 941 531 AN
Component: E1 - LDS H08 0090
Serial number: 00000000002306101420

Subsystem 4 - Part No SW: 8K0 907 410 C HW: 8K0 907 410 C
Component: HOMELINK H01 0010

4 Faults Found:
02895 - Supply Voltage for LED Module for DRL and Parking Light; Left
012 - Electrical Fault in Circuit
Freeze Frame:
Fault Status: 01101100
Fault Priority: 2
Fault Frequency: 1
Reset counter: 165
Mileage: 125246 km
Time Indication: 0
Date: 2010.01.22
Time: 00:50:00

03189 - Bulb for Side Marker Light; Front Right
012 - Electrical Fault in Circuit
Freeze Frame:
Fault Status: 01101100
Fault Priority: 2
Fault Frequency: 1
Reset counter: 165
Mileage: 125246 km
Time Indication: 0
Date: 2010.01.22
Time: 00:50:00

01516 - Terminal 30; Left
011 - Open Circuit
Freeze Frame:
Fault Status: 01101011
Fault Priority: 2
Fault Frequency: 1
Reset counter: 165
Mileage: 125246 km
Time Indication: 0
Date: 2010.01.22
Time: 00:50:00

00576 - Terminal 15
008 - Implausible Signal
Freeze Frame:
Fault Status: 01101000
Fault Priority: 2
Fault Frequency: 1
Reset counter: 165
Mileage: 125246 km
Time Indication: 0
Date: 2010.01.22
Time: 00:50:00

-------------------------------------------------------------------------------
Address 5F: Information Electr. (J794) Labels:. 4E0-035-6xx-5F.clb
Part No SW: 8T1 035 664 F HW: 8T1 035 664 B
Component: H-BN-NA H49 0189
Revision: -------- Serial number: 490G$0A7573822
Coding: 010200020206A1EF55000B0E000000030000
Shop #: WSC 06325 000 00000
VCID: 3B7E8E6DBA125292CE-806E

Subsystem 1 - Part No: 8R0 060 884 CS
Component: NAR 2015 1201

Subsystem 2 - Part No SW: 8F0 919 604 HW: 8F0 919 604
Component: DU7 High H42 0098
Serial number: 9466GS0A0036047

Subsystem 3 - Part No SW: 8T0 919 609 G HW: 8T0 919 609 G
Component: E0380 Bedient H08 0100
Serial number: 00000000578176

Subsystem 4 - Part No: 8R0 060 961
Component: CD-Database 1886

1 Fault Found:
03276 - Please Check Software Version Management
000 - -
Freeze Frame:
Fault Status: 01100000
Fault Priority: 6
Fault Frequency: 1
Reset counter: 165
Mileage: 125246 km
Time Indication: 0
Date: 2010.01.22
Time: 00:50:17

Freeze Frame:
Voltage: 14.00 V

11S5V8
01-14-2019, 07:06 AM
Hey sorry to hear about your woes. Biggest recommendation I can give you is find a good indy shop that specializes in Audi. Jobs that normally would of been 1000-1500 have been 3-500. I've always owned used cars never bought anything new and would never step into a dealership for service. Well maybe part of that's a lie bc my wifes Jeep goes to dealership for oil changes but thats $59.99 *snickers*

RobinG
01-17-2019, 08:09 PM
The hits keep coming:
-------------------------------------------------------------------------------
Address 01: Engine (J623-CAUB) Labels:. 079-907-560-CAU.clb
Part No SW: 8T0 907 560 AE HW: 8T0 907 560
Component: 4.2l V8/4V H17 0002
Revision: 76H17---
Coding: 01140009180F0120
Shop #: WSC 48635 000 1048576
VCID: 7DFA4075E4869CA2B0-8028

4 Faults Found:
004907 - Knock Sensor 4 (G199)
P132B - 008 - Electrical Malfunction in Circuit - Intermittent
Freeze Frame:
Fault Status: 00101000
Fault Priority: 2
Fault Frequency: 1
Reset counter: 255
Mileage: 124787 km
Time Indication: 0
Date: 2019.01.07
Time: 19:15:16

Freeze Frame:
RPM: 1874 /min
Load: 28.2 %
Speed: 15.0 km/h
Temperature: 85.0C
Temperature: 39.0C
Absolute Pres.: 980.0 mbar
Voltage: 13.081 V

005715 - Please check DTC Memory of ABS Controller
P1653 - 001 -
Freeze Frame:
Fault Status: 01100001
Fault Priority: 2
Fault Frequency: 4
Reset counter: 255
Mileage: 125248 km
Time Indication: 0
Date: 2010.01.22
Time: 13:36:17

Freeze Frame:
RPM: 3041 /min
Load: 27.0 %
Speed: 121.0 km/h
Temperature: 62.0C
Temperature: 8.0C
Absolute Pres.: 1000.0 mbar
Voltage: 14.351 V

005715 - Please check DTC Memory of ABS Controller
P1653 - 008 -
Freeze Frame:
Fault Status: 01101000
Fault Priority: 2
Fault Frequency: 5
Reset counter: 255
Mileage: 125248 km
Time Indication: 0
Date: 2010.01.22
Time: 13:36:17

Freeze Frame:
RPM: 3041 /min
Load: 27.0 %
Speed: 121.0 km/h
Temperature: 62.0C
Temperature: 8.0C
Absolute Pres.: 1000.0 mbar
Voltage: 14.351 V

006535 - Function Limited due to Brake Temperature
P1987 - 008 - - Intermittent
Freeze Frame:
Fault Status: 00101000
Fault Priority: 2
Fault Frequency: 1
Reset counter: 255
Mileage: 125333 km
Time Indication: 0
Date: 2019.01.14
Time: 16:56:41

Freeze Frame:
RPM: 623 /min
Load: 18.8 %
Speed: 17.0 km/h
Temperature: 100.0C
Temperature: 17.0C
Absolute Pres.: 990.0 mbar
Voltage: 14.605 V

Readiness: 0000 0000

-------------------------------------------------------------------------------
Address 03: ABS Brakes (J104) Labels:. 8K0-907-379-V1.clb
Part No SW: 8K0 907 379 BJ HW: 8K0 907 379 BJ
Component: ESP8 quattro H04 0050
Revision: -------- Serial number: --------------
Coding: 110D1A
Shop #: WSC 06325 000 00000
VCID: 020033899D78E35ACD-8056

2 Faults Found:
00526 - Brake Light Switch (F)
008 - Implausible Signal - Intermittent
Freeze Frame:
Fault Status: 00101000
Fault Priority: 2
Fault Frequency: 1
Reset counter: 165
Mileage: 125248 km
Time Indication: 0
Date: 2010.01.22
Time: 13:36:17

Freeze Frame:
Hex Value: 0x7940
Hex Value: 0x4002
Hex Value: 0x0204
Hex Value: 0x81B2
Hex Value: 0x00FF

01324 - Control Module for All Wheel Drive (J492)
013 - Check DTC Memory
Freeze Frame:
Fault Status: 01101101
Fault Priority: 4
Fault Frequency: 4
Reset counter: 168
Mileage: 125248 km
Time Indication: 0
Date: 2010.01.22
Time: 13:36:17

Freeze Frame:
Hex Value: 0x7A40
Hex Value: 0x4202
Hex Value: 0x0228
Hex Value: 0x50B4
Hex Value: 0x00FF


-------------------------------------------------------------------------------
Address 22: AWD (J492) Labels: 8K0-907-163.clb
Part No SW: 8K0 907 163 A HW: 8K0 907 163 A
Component: 4 Wheel Drive H10 0025
Serial number: 002106100001004
ASAM Dataset: EV_AllWheelDiffeQSPCAN 003016
ROD: EV_AllWheelDiffeQSPCAN.rod
VCID: 2E58B7397160B73A79-807A

1 Fault Found:
0059 - Please Check Fault Codes in Control Module for ABS Brakes
U1017 00 [137] - -
[New feature! Extended UDS fault detail is only supported by current gen. interfaces]
MIL ON - Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 6
Reset counter: 168
Mileage: 125248 km
Date: 2010.01.22
Time: 13:36:17

11S5V8
01-18-2019, 05:26 AM
I've noticed, at least on my car, multiple codes pop up for one distressed issue. Example, thermostat needed replaced and I had a slew of voltage codes and coolant/temp related codes. Had the thermostat replaced and not a single CEL since then.

Sinister_S5
01-31-2019, 08:43 PM
For the headlight issue - check the connection for the j519 at the fuse block. I had a similar issue. Dealer replaced the j519, issue continued and a month later they found the connection at the fuse box was sloppy, creating heat from the resistance, and breaking the connection. They simply crimped it better and its been A1 since. New fuse block would have set me back $400. Hope this helps!

DraiS5
02-01-2019, 04:01 PM
To clear the low oil light. Remove the oil filler cap wipe inside after the cap is removed.